OVERVIEW OF THE TYPE OF CLEANING FLUIDS USED TO CLEAN THE FUEL TANKS OF LAUNCH VEHICLES

  • О.В. Кулик Национальный центр аэрокосмического образования молодежи им. А.М. Макарова
  • П.Н. Желтов The national aerospace educational center of youth named after A.M. Makarov
  • Д.С. Абраменко Oles Honchar Dnipro National University
Keywords: MIYUCHA RІDINA, PALIVNІ TANKS, HLADON-113, WATER-MIYUCHІ RAZCHINNIKI.

Abstract

The article provides an analysis of various types of washing liquids for removing organic and inorganic contaminants from the inner surface of domestically produced fuel carrier rockets. The characteristics of the removed contaminants from fuel tanks are described. The advantages and disadvantages of the most effective fluorinated washing liquids are described, the properties of freon-113 are described in detail. In connection with the decisions made at PA YuzhMash, a number of cleaning and degreasing technological processes were revised in order to exclude Freon 113 from the technological cycle. For the bulk of DAT, the degreasing technology was changed: the dipping method was replaced by the flooding method, degreasing in the vapor-gas phase of hladon-113 at the UOF-2 unit was excluded, the operational consumption rates were revised in order to reduce them, the equipment used was revised. In addition, gasoline and water-based detergents began to be used as technological materials instead of hladon-113. The necessity of using surfactant-based washing liquids has been substantiated. The applicability of cleaning liquids has been determined depending on the design features of the surfaces to be cleaned. Requirements have been made for alternative cleaning fluids. Multicomponent hydrocarbon solvents are obtained mainly on the basis of gasoline and kerosene fractions, as well as special petroleum solvents, which are obtained by strict selection of group hydrocarbon and fractional compositions - nefras, solvents and other hydrocarbon solvents for special purposes (Petrov's contact, cresols, etc.). On the basis of the regulatory framework of the industry and international standards presented in the article, an analysis of the possibility of using existing solvents instead of hladon-113 is carried out. Recommendations for the use of types of washing liquids from the types of in-tank elements are also given.

Author Biographies

О.В. Кулик, Национальный центр аэрокосмического образования молодежи им. А.М. Макарова

Украина. Национальный центр аэрокосмического образования молодежи им. А.М. Макарова.

Генеральный директор, доцент, к.т.н.

Сфера интересов – технология производства и испытания ракетно-космических летательных аппаратов.

П.Н. Желтов, The national aerospace educational center of youth named after A.M. Makarov

Украина. Национальный центр аэрокосмического образования молодежи им. А.М. Макарова.

Начальник отдела.

Сфера интересов – технологии производства ракетно-космической техники.

Д.С. Абраменко , Oles Honchar Dnipro National University

Украина. Днепровский национальный университет им. Олеся Гончара.

Соискатель.

Сфера интересов – технология сборки и испытаний ракетно-космической техники.

References

Бедрик Б. Г., Чулков П. В., Калашников С. И. Растворители и составы для очистки машин и механизмов: монография. Москва : Химия, 1989. 176 с.

Потапович Л. П. Конструктивно-технологічні методи забезпечення чистоти ракетно-космічних об'єктів для підвищення надійності їх функціонування: дис. … канд. тех. наук: : 05.07.02 Дніпропетровськ, 2008. 165 с.

Алексєєв Ю. С., Джур О. Є., Кулик О. В., Кучма Л. Д., Ніколенко Є. Ю., Хуторний В. В. Технологія виробництва ракетно-космічних літальних апаратів: навч. посіб. / за ред. д-ра техн. наук Є. О. Джура. Дніпропетровськ : АРТ-ПРЕС, 2007. 480 с.

Шандер А. Ю. Разработка методики очистки топливных баков и магистралей летательных аппаратов на основе акустических и вакуумных воздействий. Проблемы разработки, изготовления и эксплуатации ракетно-космической техники и подготовки инженерных кадров авиакосмической отрясли : материалы XII Всероссийской науч. конф., г. Омск, 30 мая 2018. Омск, 2018. С. 126 – 132.

Экспериментальные исследования по выбору оптимального водно-моющего средства для обезжиривания поверхностей под «оксид» : Технический отчет / УкрНИИТМ. инв. № 1060. Днепропетровск, 2008. 38 с.

Экспериментальные исследования по сравнительным коррозионным испытаниям образцов, обезжиренных рекомендуемым водно-моющим средством и хладоном-113 : Технический отчет / УкрНИИТМ. инв. № 1080с. Днепропетровск, 2009. 17 с.

Published
2021-11-17
How to Cite
Кулик, О., Желтов, П., & Абраменко, Д. (2021). OVERVIEW OF THE TYPE OF CLEANING FLUIDS USED TO CLEAN THE FUEL TANKS OF LAUNCH VEHICLES. Journal of Rocket-Space Technology, 29(4), 95-105. https://doi.org/10.15421/452110
Section
Production technologies and materials